Skip to main content
Cette page n'est pas encore disponible en French. Version originale anglaise affichée. Lire en anglais →
P0402 P0xxx · Groupe motopropulseur (P) Gravité moyenne

Exhaust Gas Recirculation Flow Excessive Detected

Too much exhaust gas is entering the intake. The EGR valve is stuck open or the flow signal is over-reading, starving the mixture of oxygen.

Indication de gravité : Moyenne — conduite ou émissions affectées, à planifier cette semaine

Symptômes que vous remarquerez

  • Rough idle or stalling
  • Lack of power
  • Black smoke on diesels
  • Hard starting when hot

Causes fréquentes

Classées du plus au moins probable — commencez en haut.

  1. 1 EGR valve stuck open from carbon
  2. 2 Faulty EGR position sensor
  3. 3 Short in the signal circuit
  4. 4 Incorrect valve fitted after a repair

Comment le diagnostiquer

Le moins cher et le moins invasif d'abord — la plupart de ces codes ne sont pas un problème de pièces.

  1. ✓ Watch EGR actual vs commanded position at idle — a valve that should be closed but is not confirms the fault.
  2. ✓ Remove and inspect the valve for carbon holding it open.
  3. ✓ Check the position sensor signal sweeps smoothly across its range.
  4. ✓ Blank the passage briefly with a test plate to confirm the symptom disappears.

Options de réparation

  • Clean or replace the EGR valve
  • Clean the EGR passages in the manifold
  • Repair the position sensor wiring

P0402 — questions fréquentes

Can I blank off the EGR? +

For off-road or test purposes only. On road vehicles it is illegal in most markets and will fail inspection.

Why does it stall at idle? +

Exhaust gas displaces oxygen in the intake; at idle the engine cannot tolerate the dilution.

Confirmez le diagnostic avant d'acheter des pièces

Envoyez-nous le code, les données figées et le véhicule — nos ingénieurs vous diront quoi tester en premier.